Car manual transmission Peugeot 307

General information about manual transmission
The gearbox is housed in an aluminum alloy crankcase and is attached to the left end of the engine. It consists of the gearbox itself, the main gear and the differential. The secondary shaft gears are engaged using a...

Technical data of manual gearboxes
Gearbox BE4R. Tables 5.1, 5.2, 5.3 show the main technical characteristics of the BE4R manual gearbox MA gearbox. Tables 5.4, 5.5, 5.6 show the main parameters of the BE4R gearbox

Replacing the BE4R gearbox
To remove the gearbox: turn off the ignition and disconnect the ground wire from the battery; remove the air filter housing; remove the air intake pipe; remove the decorative battery cover; remove the battery; remove...

MA gearbox replacement
To remove the gearbox: turn off the ignition and disconnect the ground wire from the battery; remove the crankcase ventilation system pipes; remove the air filter; disconnect and remove the air filter outlet pipe;...

Replacing the BE4R gearbox housing
To remove the gearbox housing: - remove the gearbox; Caution! When disassembling and repairing the gearbox, observe the following requirements: - Do not use abrasives or tools that leave scratches on the mating...

Replacing the differential housing of the BE4R gearbox
To remove the gearbox differential housing: remove the gearbox from the car; remove the crankcase, primary and secondary shafts from the gearbox; Figure 5.34. Differential mount: 1 - mounting bolts; 2 - differential...

Replacing the differential box
To remove the differential case, do the following: remove the gearbox; remove the differential box; Figure 5.41. Using the FACOM U53 K2 universal puller (1) to remove bearings (2) from the differential case using the...

Replacing the gearshift mechanism
Figure 5.43. Gear shift mechanism: 1 - gear selection cable; 2 - reaction lever; 3 - drive cable The gear shift mechanism is shown in the figure 5.43. To remove the gear shift mechanism: Figure 5.44. Direction of...

Checking the level and replacing the oil in the gearbox
To check the level and change the oil in the gearbox: place the car on a lift in a horizontal position; the oil level/fill and drain plugs are located on the rear of the gearbox under the rear cover; clean the plugs and...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Share information:

See similar information for other Peugeot models

➨ Transmission: Manual gearbox Peugeot 106 (1991-2003)
➨ Transmission: Mechanical gearbox Peugeot 206 (1998-2012)
➨ Transmission: Manual gearbox BE Peugeot 405 (1987-1997)
➨ Transmission: Mechanical gearbox Peugeot 605 (1989-2000)
➨ Transmission: Gearbox Peugeot J5 (1981-1993)

Link to this section in different formats

TEXTHTMLBB Code